Ulje za mjenjače M40, M45, M46, M47


Sve u vezi Volvo/Saab servisa / All about Volvo/Saab repair shops

User avatar

Joined: 24 Jan 2013 11:32

Location: Zg

Volvo: 244 DL

Post 31 Jan 2014 14:52

Ulje za mjenjače M40, M45, M46, M47

Kole wrote:Obrati paznju na to menjacko ulje. 98% majstora i prodavaca koji nisu specijalizovani za volvo ce ti nehotice uvaliti klasicno menjacko ulje tipa sae 90 ili 80W90. A to je skoro sigurna brza smrt za 5. brzinu ovog menjaca. U tvoj menjac ide sinteticko VOLVO ulje 1161324 ili u zameni ATF tip F ili tip G. A ova ulja je tesko naci...
PS. Bolje da i ne menjas to ulje u menjacu nego da sipas pogresno. ;)


Slična mišljenja sam vidio na još nekim forumima, ali isto tako na mnogo mjesta se gura ulje sae 80W90.

Pa evo par različitih mišljenja:

br.1:
Kako meni treba ulje za M40 mjenjač, zvao sam MotoRis (Volvo servis) i rekli su mi iz servisa da u sve te starije mjenjače i diferencijale ide obični HIPENOL, tj. sae 80W90.

br. 2
Na stranicama firme Comma Oil http://www.hr.commaoil.com/products/results/91001335 deklariraju da za ručni mjenjač M45, M46, M47 ide ulje AQF (Automatic transmission fluid), a za stražnji diferencijal EP80W-90 GL-5 ili LS80W-90 GL-5.

br. 3
All 140 series Volvos (without overdrive) equipped with the M40 gearbox use SAE 80 gear oil, or if none is available, SAE 30 engine oil. All 140 series Volvos with overdrive and all 1800 series Volvos equipped with the M410 gearbox use SAE 30 or SAE 20W-40 engine oil. Model 164 Volvos, without overdrive, and equipped with the M400 gearbox use SAE 90 gear oil or SAE 40 engine oil.

1975 240 series Volvos equipped with the M40 transmission use SAE 80W/90 or SAE 80/90 gear oil, while all 1975 240 series Volvos equipped with the M41 overdrive transmission use SAE 30 or SAE 20W-40 oil.

On a number of 1976 240 series and 260 series models equipped with the M45 transmission and the M46 overdrive transmission, the transmissions are filled with SAE 80W/90 or SAE 80/90 gear oil, while all other M45 and M46 transmissions (used on 1976-88 models) are filled with Type F or Type G automatic transmission fluid. You are reading that correctly; automatic transmission fluid in a manual (stick shift) transmission. An easy way to tell if the transmission uses gear oil or ATF is: on ATF filled transmissions, the figure eight shaped flat casting located at the filler plug is stamped "ATF-OIL" in white. Do not attempt to use gear oil in these transmissions, or vice versa. The M47 5-speed transmission introduced in 1987 also uses Type F or G fluid.

br. 4 (Volvo instruction book for M40/M41)
The oil level in to the transmission should be checked after every 3,000 miles
(5,000 km). The oil level should be up to the filler hole.
The oil in the transmission should be changed after every 12,500 miles (20,000
km).(In the case of a new or reconditioned transmission, the oil should be changed
after the first 3,000 miles (5,000 km) and the transmission should also be carefully
rinsed out with flushing oil)
The old oil should be drained off immediately after the car has been run while the oil
is still warm. Every other time the oil is changed, the transmission should be cleaned
out with flushing oil before the new oil is added.
When draining off the oil from a transmission fitted with an overdrive, note that there
is an extra drain plug under the overdrive marked “Drain”. When oil is being added it
takes some time for the oil to run into the overdrive and for this reason the filling
should be carried out relatively slowly. Each time the oil us changed, the overdrive oil
strainer should be cleaned – see servicing procedure 25 page 25
Do not use hypoid oil in the transmission.

M40 Transmission oil SAE 80 (all year round) 0.75 litres
M41 Engine oil SAE 30 (all year round) 1.8 litres


Ako sam ja dobro skužio za M40 ide SAE 80, a za M45, M46 i M47 treba koristiti ATF. Ispravite me ako sam u krivu.

Joined: 01 Feb 2013 00:28

Volvo: 244, 940T

Post 01 Feb 2014 00:53

Re: Ulje za mjenjače M40, M45, M46, M47

M40-hipenol. Overdrajv i m47 ja sam uvjek imao obicno motorno ulje, ne atf. Ni jedna nije crkla.
Ju dont hev mani tu pej maj tajm.
User avatar

Joined: 22 Jan 2013 12:09

Location: Beograd Srbija

Volvo: nekoliko komada serije 7/9

Post 01 Feb 2014 15:35

Re: Ulje za mjenjače M40, M45, M46, M47

Ja konkretno imam iskustva sa ne ispravnim M46/47. I ima tamo oko kuce mislim par losih za delove. Svaki los koj sam skidao sa kola je imao pogresno ulje. Lako (okom) vidis da je gusce i (nosom) osetis da je smrdljivo hipoidno sto ljudi greskom gurnu u M46/47. Motorno ulje 10W40 koje sam i ja sipao u nedostatku originalnih takodje nikad nije napravilo probleme.
Ali sam pobornik teorije(za M46/47): Samo proveris nivo i ako je unutra fino crveno fabricko ulje nebitne starosti ne diras nista. :driv:

Return to Servis

Who is online

Users browsing this forum: No registered users and 0 guests

cron
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group.
Designed by ST Software Change colors.